ESC repair help Novak T-4

Brushless, lipo, spectrum, etc...

Moderators: scr8p, klavy69

Post Reply
aconsola
Approved Member
Posts: 1998
Joined: Fri Feb 16, 2007 10:09 pm
Location: Upstate NY
Been thanked: 12 times

ESC repair help Novak T-4

Post by aconsola »

I picked up a used dirty novak t4 untested. It had frayed receiver wire but otherwise intact. I replaced the wires after cleaning everything up and soldering on fresh connectors.

Plugged in to rx with a battery and it powers up the rx and servo no problem.
I set the tx direction, adjusted the center and high pots on the esc so the light goes on and off as it should.
Everything looks like it is working fine so I plugged in a known working motor and nothing happens with throttle input on the tx.
The esc light goes on and off indicating throttle, full throttle, and brake, but no power to the motor.
The esc doesn't get warm at all, no visible signs of burnt mosfets.
If I disconnect the rx and with the case open Jump the + bat wire to the Gate lead on a couple of the forward fets the motor receives power.

There are no burnt traces, loose wires or bad solder joints that I can see.
I'm at my limit of electronics knowledge.

Does anyone have any suggestions for how to repair this ESC?

It actually looks quite nice now all cleaned up, might just have to be for a shelfer that isn't going to get run anyway.

User avatar
jwscab
Super Member
Posts: 6479
Joined: Wed Jan 28, 2009 9:42 am
Location: Chalfont, PA
Has thanked: 10 times
Been thanked: 434 times

Re: ESC repair help Novak T-4

Post by jwscab »

it sounds like whatever components are in series with the gate drive are blown out, which is odd, but who knows. where you applie + to get the motor to spin, look at the components and see what is in series, probably a resistor, I believe the drive circuit might have a boost voltage and that may be bad, there are a few transistors in that path that could have gone bad.

threesheds
Approved Member
Posts: 397
Joined: Sun Jan 21, 2018 10:05 am
Location: Beckenham, Kent, uk
Has thanked: 60 times
Been thanked: 83 times

Re: ESC repair help Novak T-4

Post by threesheds »

I guess you're all talking brushless these days but 'not' in this case, but I got a £8 320A off ebay, seems to work fine. Although the first one received had a dodgy on/off switch but the vendor sent a replacement, now I have two after repairing the dodgy ones switch, no extra cost from vendor.
point is unless its worth more than $50/£40 is spending more than an hour on it is a waste of time. with so much 'inside' silicon chips it looks like a bin job.

aconsola
Approved Member
Posts: 1998
Joined: Fri Feb 16, 2007 10:09 pm
Location: Upstate NY
Been thanked: 12 times

Re: ESC repair help Novak T-4

Post by aconsola »

thanks for the input. I looked at the circuit again. tested a few of the resistors in series and they look good. Looks like a chip may be bad. Ohh well. it will look nice on a display car.

User avatar
jwscab
Super Member
Posts: 6479
Joined: Wed Jan 28, 2009 9:42 am
Location: Chalfont, PA
Has thanked: 10 times
Been thanked: 434 times

Re: ESC repair help Novak T-4

Post by jwscab »

yeah, you would have to put a scope on it to see if things are switching as necessary. otherwise, she'll look good on the shelf.

User avatar
matt1ptkn
Approved Member
Posts: 910
Joined: Wed Dec 12, 2012 8:27 am
Location: Moundsville, WV
Has thanked: 80 times
Been thanked: 132 times

Re: ESC repair help Novak T-4

Post by matt1ptkn »

I have a minty T4 case from an ESC that sounds similar to yours, if you need a case for display purposes. Its such a let down when you buy an electronic device and it doesn't work. :|
Matt

Just a part of my RC collection: Matt1ptkn's Toys

"I wish there was a way to tell you're in the good old days, before you've actually left them."

Post Reply

Create an account or sign in to join the discussion

You need to be a member in order to post a reply

Create an account

Not a member? register to join our community
Members can start their own topics & subscribe to topics
It’s free and only takes a minute

Register

Sign in

  • Similar Topics
    Replies
    Views
    Last post
  • Orange or Black Novak ESC Switch Repair
    by nicholasdivitto » » in Vintage Electronics
    0 Replies
    131 Views
    Last post by nicholasdivitto
  • How to repair a Novak Nes 1a
    by prp » » in Vintage Electronics
    0 Replies
    983 Views
    Last post by prp
  • Possible to repair novak havoc?
    by soniccj5 » » in Modern Electronics
    9 Replies
    1578 Views
    Last post by GoMachV
  • Novak ESC Profile Software (97) & Novak Cyclone (99)
    by teman » » in Vintage Electronics
    8 Replies
    1691 Views
    Last post by teman
  • Anyone repair ESC's, or know of someone who does?
    by R6cowboy » » in Vintage Electronics
    3 Replies
    216 Views
    Last post by dinglem
  • Repair Futaba MC 210CB ESC
    by whyme » » in RC10 Buggy Forum
    21 Replies
    3664 Views
    Last post by whyme
  • Old Novak ESc or newer style Traxxus ESC
    by k9medic » » in Vintage Electronics
    6 Replies
    1386 Views
    Last post by scr8p
  • ESC repair, fried transistor- I need help from an expert!
    by 85Edinger » » in Vintage Electronics
    43 Replies
    5412 Views
    Last post by scr8p

Return to “Modern Electronics”

Who is online

Users browsing this forum: No registered users and 19 guests